rfaspen
[insert pithy phrase here]
...
My process for shortening the lens tube was rather low tech, but I ensured that it worked well, and very precise.
First, I used a "marking gauge" to mark a line around the lens tube that was about 12mm from the newly flattened end. That's less than the 13.8mm I anticipated I would need to remove: my plan was to sneak up on my final tube length by slowly removing material and checking infinity focus, removing more material (if needed), checking infinity focus, remove material.....until I get what I want.
The marking gauge I used is a common woodworkers tool. Sorry I don't have a ready image of it, but it consists of a fence and post with a sharp "scratch point" held at an adjustable distance from the fence.
I then used my jewelers saw to cut the lens tube at the scratch line around the tube. My jewelers saw is an adjustable version with a 5-inch blade that is actually a diamond-encrusted wire. I am confident that a thin-bladed hacksaw would have worked equally well here.
Once I made my cut, I needed to free the mounting flange that was epoxy glued into the end (the flattened T-mount). I made a short cut and pried the tube off the flange.
You can see where I cleaned the inside surface of the flange to bare metal. Necessary for a good epoxy bond later.
Now, time to shorten the tube.
I used a common technique in the woodworking shop. Sandpaper attached to float glass (plate glass) with a light spray adhesive. I then placed the tube end on the grinding surface and ground away with circular motions.
After some initial grinding to smooth the tube end, I used my caliper micrometer to check the tube length all around the tube. My initial cut with the jewelers saw was remarkably precise and the tube length was almost consistent all around. I marked the "high points" where the lens tube was a little longer with some sharpie and made a few grinds with added pressure at that point. Then checked again with the micrometer. Did that a few times until I had a consistent tube length all around (to about 0.05mm).
Then I just ground with the circular motion with even pressure and the tube remained consistent.
It took a LOT of grinding and checking infinity focus to arrive at my final length. I checked infinity focus by putting the M flange mount in the visoflex, then inserting the flat flange (that I just freed from the lens tube) into the tube, attached the lens tube into the remainder of the lens, and held the whole thing together while looking through the visoflex. I sighted on a ridgeline of trees about a mile away.
My process for shortening the lens tube was rather low tech, but I ensured that it worked well, and very precise.
First, I used a "marking gauge" to mark a line around the lens tube that was about 12mm from the newly flattened end. That's less than the 13.8mm I anticipated I would need to remove: my plan was to sneak up on my final tube length by slowly removing material and checking infinity focus, removing more material (if needed), checking infinity focus, remove material.....until I get what I want.
The marking gauge I used is a common woodworkers tool. Sorry I don't have a ready image of it, but it consists of a fence and post with a sharp "scratch point" held at an adjustable distance from the fence.
I then used my jewelers saw to cut the lens tube at the scratch line around the tube. My jewelers saw is an adjustable version with a 5-inch blade that is actually a diamond-encrusted wire. I am confident that a thin-bladed hacksaw would have worked equally well here.
Once I made my cut, I needed to free the mounting flange that was epoxy glued into the end (the flattened T-mount). I made a short cut and pried the tube off the flange.

You can see where I cleaned the inside surface of the flange to bare metal. Necessary for a good epoxy bond later.

Now, time to shorten the tube.
I used a common technique in the woodworking shop. Sandpaper attached to float glass (plate glass) with a light spray adhesive. I then placed the tube end on the grinding surface and ground away with circular motions.

After some initial grinding to smooth the tube end, I used my caliper micrometer to check the tube length all around the tube. My initial cut with the jewelers saw was remarkably precise and the tube length was almost consistent all around. I marked the "high points" where the lens tube was a little longer with some sharpie and made a few grinds with added pressure at that point. Then checked again with the micrometer. Did that a few times until I had a consistent tube length all around (to about 0.05mm).
Then I just ground with the circular motion with even pressure and the tube remained consistent.
It took a LOT of grinding and checking infinity focus to arrive at my final length. I checked infinity focus by putting the M flange mount in the visoflex, then inserting the flat flange (that I just freed from the lens tube) into the tube, attached the lens tube into the remainder of the lens, and held the whole thing together while looking through the visoflex. I sighted on a ridgeline of trees about a mile away.
